What parts have you replaced?

[prerunner1982]

How long have you owned your XJ and what parts have you replaced (not due to damanges obtained off road).

I have had my XJ for 5yrs (?) and approx 60K miles.

So far I have replaced:
Power steering pump
Ignition Coil
CPS (was not broke and didn't fix the problem I was having, but replaced anyways)
All tie rod ends
Track bar
Headlights
Alternator
Water pump

Radiator will be in the very near future.

[OrangeXJ]

evert thing you hve done excetp anew eingine

[prerunner1982]

I didn't think it was too bad for a 20yr old vehicle. Not telling if/when those parts were replaced previously... The front steering was problem the most expensive "item".

[prcjeep]

My Jeep is disqualified from being listed in this thread...

[NW99XJ]

I've had my XJ for about 3 years, over 100k put on it, and countless trips on the trails.
So far....I've replaced:

cap/rotor
plugs
wires

all fluids (duh)

alternator
all wiring associated with the charging system
fusable link

all suspension components
front sway bar bushings too

front brake pads & rotors
all brake lines

flasher/hazard/turn signal relay

front passenger window regulator

powah steering high pressure line

exhaust manifold

every last U-joint (and some a couple of times)

rear hatch struts

crank position sensor

throttle position sensor

headlight housings (H4 upgrade) <-- and various bulbs

transfer case rear output shaft seal (at time of SYE)

front axle tube seals (inner) .....twice.

nut strips

wheels/tires

Various nuts and bolts throughout.....
(and i'm sure there's more)

[4.3LXJ]

It is easier to list what I haven't replaced. So far everything except the stock axles, although some parts in them and the unibody

[prcjeep]

It is easier to list what I haven't replaced. So far everything except the stock axles, although some parts in them and the unibody

Im with Steve on this one... other than body parts/unibody everything has been replaced... except the down pipe to the front of the cat, gas tank/skid bumpers

[LizardRunner]

most of mine were installed by the po so i'm disqualified for now.

[Carves]

damn you Prerunner1982 .. :P


I was only thinking the other day ... how the l'il wagon has passed five or six yearly inspections without needing repairs ..


This morning Ive been remembering things like exhaust manifolds, welch plugs, rear main seal ... and that annoying dvrs power window switch ... done between inspections ...


and a bunch of other general wear & tear stuff .. :rolleyes: .. :D

[cantab27]

nothing as i look after my jeeps.....:D

[XJ Wheeler]

Had Stormy for oh, almost nine years. Been pretty blessed so far. Hard to remember everything though, and some of this is purely an upgrade while some others are repairs turned upgrades. :D

Repairs:
Radiator (twice)
Thermostat (twice)
Upper (twice) and lower (once) radiator hoses
Heater hose
Thermostat housing
Fan clutch
Optima blue top (twice)
Calipers (twice)
Front right hard brake line
Power steering pressure line
Front sway bar swapped for one from an '89 sport (original rusted)
Rear bumper swapped for one from the same '89 (original smashed)
Defroster vacuum actuator (that it was the problem, wasn't)
Driving lights on bumper (old ones didn't work)
Power antenna (old one didn't work and was bent up in hurricane, new one still doesn't work, must have another problem)
Catback (original was rusted)
Right tail light (original was smashed)
Both tail lights (Jeep 2500 versions, gift)
Headlights (old ones started fogging up inside, got Silverstars)
Steering stabilizer (for a Rancho unit)
Firepower ignition kit (coil, plugs, wires, rotor)
Front brakes (ebc rotors and yellow stuff pads)
Suspension (well, my stock leaf springs were sagging :D )
Front bumper mounts swapped for tow hook versions
Almost all bulbs for LEDs
Front turn signal housing (custom LED project)
Right front fender flare
Radio and speakers


It doesn't get driven a lot, or i know this list would be a LOT longer.

[Brasscatz]

Owned it 2 years, 200,000 miles on the ODO

Entire cooling system except the radiator (soon to come)
Steering upgrade to zj tie rods
Adjustable Track Bar
Suspension parts/lift
Radio
Speakers
U-Joints
Wheel bearings
Motor Mounts

[nickxj94]

Owned my 94 for going on two years now.
Replaced fuel pump, tank straps rusted, cps went through 4 of them, front brakes and rotors, rear disc conversion from Zj, plugs, wires, cap and rotor, lift, shocks, stabilzer,swaybar bushings, Lca's,radio, speakers, headlights went to H4s, 98 seats and console, winch and homemade bumper, wheels and tires, tail lights, front axle shafts upgraded to Tj big ujoints, new ujoints in front drive shaft, new rear drive shaft old one was bent,repaired rusted floors, upgraded to 98 xj flairs, think that's about it :D

[nickxj94]

2000 xj owned for a year,
Replaced coil rail, plugs, radio, 12 inch subs and 1000 Watt amp, headlights h4 upgrade, lift, wheels and tires, battery, alternator, belt,clutch fan, harmonic balancer, adjustble trackbar, swaybar bushings, air box, brushgaurd, rewiring on a bunch of stuff under hood that was shorting out, both o2 Sensors twice!

[98FloridaXJ]

1998 XJ that I've owned for a year now, I've replaced:
All cooling components
Exhaust Manifold
Driver side motor mount
Radio and speakers
Re did the head due to a bad exhaust valve
Muffler
3" lift due to worn factory shocks
Tranny solenoids

I'm sure there might be more but I can't remember any others.

[89Laredo]

Had this jeep for a year (I wont list the other two)

Cap/rotor/plugs
Fuel filter
Thermostat/gasket
Coil and ICM
Radiator
Oil filter adaptor o rings
Battery
Motor mounts
Valve cover gasket (needs to be done again. Pan gasket needs done)
Rear speakers (put sound bar in)
Ground cables
Fuel injectors
Front and rear end swap/lift/tires and rims
Steering Column
Radio
Water pump
Front bumper
Throttle body/TPS/IAC
TB gasket (x3 I think)
Fan clutch
Pitman arm
Track bar
Track bar mount
Ujoints
Intake/exhaust gasket
Fuel injector connectors (from old style to new style)
Brake booster/master cylinder (Think Im going to a Grand MC soon, Dont think my rear disks are working as good as they should)
Front brake pads
Rear brake springs when it had the turdy5
Im sure theres more Im forgetting...

[msmoorenburg]

On my current 97

well i haven't replaced all of the sheet metal :ass:

all running gear was replaced

front axle from 96
engine from 96
tranny from 99
rear axle was 35 now 29spline 8.25
gas tank from 98
radiator/condenser from 99

oh the power steering pump is original

[Joliet Johnny]

Water pump
Radiator
Thermostat
All belts
All hoses
License plate light
Radio-didnt come with one
Tune up-cap, plugs, wires, rotor, air filter
Rear brakes-drums, shoes, hardware, wheel cylinders
Rear brake lines
Many fuses for the power locks

[cpttuna]

Luck must be on my side. With all the XJ's in the family, I have changed some parts(like ss exhaust on all the jeeps). The only part so far That I have had to replace because the old one went bad was a power steering pump on the son's 01.

[nickyg]

Well, Let's just say one more part and I'll have a new jeep.

[saar]

2001 xj, with me for the last 9 years:
Radiator x2
A/c evaporator core
Cps
Water pump
Thermostat x2
Coolant hoses
Cylinders head gasket & valves sealants
Rear oil sealant (engine)
3.5" lift includes coil springs, shocks rear leafs etc
Steering stabilizer x2
Control arms bushings
Rear leafs bushings
Cv joints
Front case bearings
Front axe shaft
Rear diff oil sealant
LSD discs
Drums
Front brakes
Ball joints
Tires x2 sets
Rear door shocks
O2 sensors
Iac
Electric vent
Ac compressor sealant

I think that is all...
Saar